Go Back   Jeep Garage - Jeep Forum > Jeep Platform Discussion > Grand Cherokee - WK > Troubleshooting/Problems

Join Jeep Garage Today
Reply
 
Thread Tools Display Modes
 
  #1  
Old 04-21-2012, 02:42 PM
Member
My Jeep: 2005 5.7L WK
 
Join Date: Apr 2012
Location: Washington
Posts: 52
Thanks: 0
Thanked 0 Times in 0 Posts
Rep Power: 912
jmc2004 is on a distinguished road
05 wk 5.7 obd code p0430

First time poster...be gentle..lol...So, I have a p0430 code popping up,and before I start throwing money at it,I had a few questions. Would sub par fuel cause the code to pop up? I have had it cleared and it was off for 2 days before it came back. I was also curious how big of an exhaust leak would cause it and where to look for one as I have read that may be the culprit. Is replacing the o2 sensors a good place to start? Some people say that its unlikely that they are bad. Will it hurt anything besides emissions if i let it go for a while or could it damage anything? Any help is much appreciated! Thanks!
__________________

__________________
Reply With Quote
  #2  
Old 04-28-2012, 07:35 PM
Member
My Jeep: 2006 5.7L WK
 
Join Date: Dec 2009
Location: Home of the Mountain Blue Bird
Posts: 994
Thanks: 0
Thanked 19 Times in 17 Posts
Rep Power: 154904
jeepgcoman has a reputation beyond reputejeepgcoman has a reputation beyond reputejeepgcoman has a reputation beyond reputejeepgcoman has a reputation beyond reputejeepgcoman has a reputation beyond reputejeepgcoman has a reputation beyond reputejeepgcoman has a reputation beyond reputejeepgcoman has a reputation beyond reputejeepgcoman has a reputation beyond reputejeepgcoman has a reputation beyond reputejeepgcoman has a reputation beyond repute
Re: 05 wk 5.7 obd code p0430

How many miles on your 05? I suppose it is possible for bad fuel to cause this, and leaded fuel will, for sure. If you have over ~75K on it and are not sure if the O2 Sensors have ever been changed, I would probably change them. I had a lazy one on my WK and changed all four. Cost is about $120, or so. Labor is ??? I just got back from a ~2000 mile trip with my Hemi LX and noticed a lazy one on it. It only has 53K on it....the WK's went out at just over 60K. Strangely, the lazy ones were both in the same position, the 2/1 sensors, or passenger side front. If a sensor or sensors is bad your fuel economy will probably be sub-par too. Before you change them, go ahead and check for exhaust leaks though, just for giggles. I imagine a leak could trigger a code, but I had a pretty good leak at a header flange gasket and didn't get a code. It did send a false lean signal to the PCM and my fuel economy tanked as a result. Good luck on your search. Hope it's not a cat. They can be spendy.
__________________

__________________
05 LX/RT & 06 WK/GCO, modded similarly, MDS "ON" Light, Vortex Gens, Debadged, DashHawk, BT Catch Can, SRT CAI W/Add Air Inlet, K&N Filter, Sonnax Trans Press Booster, SC Tuner W/Adv Trans Tuning App, DS Tuner, Cust tube headers w/3 in. catback, Bilsteins, SRT frt/rear bumpers, Eibach SRT Lwr Sprgs & Sways, FRI Sidewinder Cam Adv 2*, 6.1 valvetrain, SLP 25% UD Pulley, BBK 90mm TB, SOS Coils/.060 plug gaps. 20 in. SRT Reps.
Reply With Quote
  #3  
Old 04-29-2012, 01:39 AM
2005JGC's Avatar
Senior Member


My Jeep: 2005 4.7L WK
 
Join Date: Nov 2010
Location: Portland, OR
Posts: 2,751
Thanks: 51
Thanked 69 Times in 58 Posts
Rep Power: 1652948
2005JGC has a reputation beyond repute2005JGC has a reputation beyond repute2005JGC has a reputation beyond repute2005JGC has a reputation beyond repute2005JGC has a reputation beyond repute2005JGC has a reputation beyond repute2005JGC has a reputation beyond repute2005JGC has a reputation beyond repute2005JGC has a reputation beyond repute2005JGC has a reputation beyond repute2005JGC has a reputation beyond repute
Re: 05 wk 5.7 obd code p0430

the catalyst monitor uses the downstream oxygen sensor to determine how fast it switches, when it mimics the upstream o2 sensor close enough, at least close enough to break a threshold it throws the code. Poor fuel could contribute to this in the long run (and NEVER suggested in even your lawn mower let alone your expensive transportation). But your likely looking at a catalytic converter, iirc the P0430 is bank 2 but either way if you were to get a y pipe from chrysler it would include both.

I will say, my sister bought a mazda pickup, brought it to my parents mechanic because it have a P0420 code, he replaced the cat and it kept coming back, he then proceded to replace 1 oxygen sensor at a time each time not fixing it still until I convinced her to bring it to the dealer, they clearly showed her on a graph the downstream switching like the upstream and told her she needed a cat, she brought it back to have her cat warrantied at my parents mechanic and after trying one last thing (not working) he finally replaced the cat again and viola, no check engine lamp... If for some reason your under 80k miles this should be a free repair due to the federal extended 8/80 warranty.

Also it is not uncommon for this dtc to not reset for a couple days, it takes driving about 55mph, in the neighborhood of 1800 rpm with light throttle apply for a specific amount of time to run the o2 monitors which must run before the catalyst monitor will run, THEN the catalyst monitor will run.
__________________
2005 Jeep Grand Cherokee - Gone but not forgotten!

Reply With Quote
  #4  
Old 04-30-2012, 08:18 PM
Member
My Jeep: 2005 5.7L WK
 
Join Date: Apr 2012
Location: Washington
Posts: 52
Thanks: 0
Thanked 0 Times in 0 Posts
Rep Power: 912
jmc2004 is on a distinguished road
Re: 05 wk 5.7 obd code p0430

Thanks for the info guys. I was considering cutting the cat out and replacing it with a new one,rather than buying a whole new y pipe. I have seen some people on here do it with the 4.7,but I havent seen anyone post anything about doing it with the 5.7,so I was curious if the tube diameter was the same and which after market cat would be best.
__________________
Reply With Quote
Reply

Thread Tools
Display Modes

Posting Rules
You may not post new threads
You may not post replies
You may not post attachments
You may not edit your posts

BB code is On
Smilies are On
[IMG] code is On
HTML code is Off
Trackbacks are Off
Pingbacks are Off
Refbacks are Off


Similar Threads
Thread Thread Starter Forum Replies Last Post
Inexpensive OBD-II padgett Grand Cherokee - WK2 - 10 11-30-2012 09:02 AM
How to tell when OBD II monitors are cleared? prsdrat Troubleshooting/Problems 2 01-24-2012 12:37 PM
OBD P1762 (M) Help/Suggestions Amelie Troubleshooting/Problems 5 08-01-2011 01:47 PM
P0430 Code and AirBag Light HEEP-IN 19 Grand Cherokee - WK 6 03-29-2011 06:34 PM
Should I erase an OBD II code? adesisto Troubleshooting/Problems 2 01-11-2010 09:16 AM

Powered by vBadvanced CMPS v3.2.3

All times are GMT -5. The time now is 10:49 AM.


Powered by vBulletin® Version 3.8.8 Beta 4
Copyright ©2000 - 2014, vBulletin Solutions, Inc.
Copyright 2012 - JeepGarage.Org
The Jeep Grand Cherokee Owners Community