Jeep Garage  - Jeep Forum

Jeep Garage - Jeep Forum (http://www.jeepgarage.org/forums.php)
-   Troubleshooting/Problems (http://www.jeepgarage.org/f203/)
-   -   2003 Jeep Grand Cherokee Limited 4.7. Air is hardly blowing. (http://www.jeepgarage.org/f203/2003-jeep-grand-cherokee-limited-4-7-air-is-hardly-blowing-39694.html)

AODetail 03-24-2012 05:13 PM

2003 Jeep Grand Cherokee Limited 4.7. Air is hardly blowing.
 
I've did the AZC self-diagnostics and its reading no codes. The blend door works fine and so does the Recirc door. The air is Cold and the Heat is hot. But it continues to hardly push any air out of the vents. The blower motor seems to be pushing really hard? I'm confused.

Frango100 03-24-2012 05:36 PM

Re: 2003 Jeep Grand Cherokee Limited 4.7. Air is hardly blowing.
 
Was any repair done to the blower motor controller lately? I know of several cases where wrongly connected controller wires did the blower motor turn in the opposite direction, causing almost no flow.

AODetail 03-24-2012 05:44 PM

Re: 2003 Jeep Grand Cherokee Limited 4.7. Air is hardly blowing.
 
According to the diagram on the blower it appears to be spinning in the proper direction. I just pulled the motor down to see the Recir door and it's operating properly. As far as previous repairs I am unsure I just recently purchased the vehicle. If this is the problem how I do I reverse it? I did notice some new looking wires and connectors appear to be going to a small control box (Relatively near the Blower Motor) which eventually leads to the blower motor.

AODetail 03-24-2012 05:49 PM

Re: 2003 Jeep Grand Cherokee Limited 4.7. Air is hardly blowing.
 
Thank you for ensuring I double checked this! It is in-fact spinning the improper direction. Where should I go from here?!

Frango100 03-24-2012 10:03 PM

Re: 2003 Jeep Grand Cherokee Limited 4.7. Air is hardly blowing.
 
1 Attachment(s)
The blower motor connectors are well known to give problems. They probably start getting a bad contact over time and the (low) resistance heats it up, causing it to melt.
Attached the wiring schematic for your reference, but i think that if you just swap the 2 wires from the blower motor to the controller, that you just reverse the direction.

AODetail 03-24-2012 10:24 PM

Re: 2003 Jeep Grand Cherokee Limited 4.7. Air is hardly blowing.
 
Quote:

Originally Posted by Frango100 (Post 600069)
The blower motor connectors are well known to give problems. They probably start getting a bad contact over time and the (low) resistance heats it up, causing it to melt.
Attached the wiring schematic for your reference, but i think that if you just swap the 2 wires from the blower motor to the controller, that you just reverse the direction.

I fixed it just prior to this message! Thank you very much however!

Frango100 03-24-2012 10:32 PM

Re: 2003 Jeep Grand Cherokee Limited 4.7. Air is hardly blowing.
 
Good to hear its fixed.:thumbsup:


All times are GMT -5. The time now is 01:19 AM.

Powered by vBulletin® Version 3.8.8 Beta 4
Copyright ©2000 - 2014, vBulletin Solutions, Inc.
Copyright 2012 - JeepGarage.Org
The Jeep Grand Cherokee Owners Community