Jeep Garage  - Jeep Forum

Jeep Garage - Jeep Forum (
-   Troubleshooting/Problems (
-   -   fuel pump wire harness (

viper4024 11-03-2012 02:57 PM

fuel pump wire harness
i'm trying to get the wire harness quick disconnect apart and i'm failing to do so. used a screw driver to try to pry it apart but it's seized together. i've been fighting with it for a half hour now and it's the last thing to get apart before dropping skid plate/tank.

any advise is appreciated

Frango100 11-03-2012 04:16 PM

Re: fuel pump wire harness
I did drop my tank some years ago and i don't remember any problems with the connectors. Also don't remember exact which type of connector it has. Is it one with a small red tab?

viper4024 11-03-2012 04:43 PM

Re: fuel pump wire harness
yeah, it had a small red clip. i did get it after a bit more fighting. had some sand and dirt in it causing it to stick. grabbed a small jewelers screwdriver and pried it apart at the base.

i've got questions about the plastic fuel lines too. fuel leak i have is caused by the metal connection above the tank corroded away. pretty much snapped right off when i grabbed it. i'm wondering if patching them up with rubber hoses and clamps would suffice or if i have to drop the load of money to replace them.

Frango100 11-03-2012 06:23 PM

Re: fuel pump wire harness
I do think that, due to the pressure which is in that line, that it would be better (safer) to use a metal line again. Ask around at the dealer, maybe its even not that expensive.

All times are GMT -5. The time now is 09:13 AM.

Powered by vBulletin® Version 3.8.8
Copyright ©2000 - 2017, vBulletin Solutions, Inc.
Copyright 2012 - JeepGarage.Org
The Jeep Grand Cherokee Owners Community