Jeep Garage  - Jeep Forum

Jeep Garage - Jeep Forum (http://www.jeepgarage.org/forums.php)
-   Grand Cherokee - WK2 - (http://www.jeepgarage.org/f73/)
-   -   NHTSA probes headliner fires (http://www.jeepgarage.org/f73/nhtsa-probes-headliner-fires-71413.html)

Dan JGC 02-08-2014 01:08 AM

NHTSA probes headliner fires
 
If you have read my other posts over the last 3 years, you will know I am a Jeep Grand Cherokee enthusiast. So, please don't take this post as disparaging, merely informative especially for anyone doing any modifications to the headliner/vanity lighting of their GC. Apparently the very very very small number of headliner fires is the result of visor wiring being pierced by one of the three screws that holds the wiring in place. The risk is very minuscule, but if you work on your vehicle it is good to know to exercise caution to make sure the wires don't get shorted when you work in that area...the odds of a defective installation from the factory are practically zero. Just passing this along.

Jan 15, 2014
"WASHINGTON — The National Highway Traffic Safety Administration has upgraded an investigation into an estimated 593,299 2011-'13 Jeep Grand Cherokee and Dodge Durango vehicles after reports of headliners catching fire.

"There may be a total of 52 unique fire incidents, including three injury allegations on Grand Cherokee and Durango vehicles," said a notice posted on the NHTSA Web site.

Chrysler told Edmunds, "Our engineers are probing this concern while also fully supporting the National Highway Traffic Safety Administration's investigation."

The vehicles have not been recalled at this point. Federal safety regulators have opened an "engineering analysis," a move that sometimes precedes a vehicle recall.

"Customers reported a range of fire conditions ranging from minor overheating to an open flame at the headliner and/or sun visor material while driving the vehicle," said NHTSA in its summary of the probe. "In some reports, the fire spread to the front seats and/or door panels of the vehicle. In one report, the sunroof was damaged, causing the glass to shatter."

NHTSA said the cause of the fires is an electrical short in the vanity lighting wiring circuit that is routed to either one of the sun visors. The visors are mounted to the roof of the vehicle through the headliner with three screws.

The visor wiring may be penetrated or pierced by one of these screws either during initial vehicle assembly or subsequent headliner area repairs.

"The piercing causes an electrical short that could result in a fire," NHTSA said.

The Durango uses the same headliner assembly as the one in the Grand Cherokee and Chrysler "indicates there are similar headliner fire incidents affecting this model, therefore, these vehicles have been added to the scope of the investigation," NHTSA said."

somedaycts 02-08-2014 08:22 PM

Re: NHTSA probes headliner fires
 
Thanks for posting this, good information to know.

bill_de 02-08-2014 09:35 PM

Re: NHTSA probes headliner fires
 
Nothing disparaging in your reporting.

It's information everyone should be aware of.


All times are GMT -5. The time now is 01:21 PM.

Powered by vBulletin® Version 3.8.8 Beta 4
Copyright ©2000 - 2014, vBulletin Solutions, Inc.
Copyright 2012 - JeepGarage.Org
The Jeep Grand Cherokee Owners Community