Jeep Garage  - Jeep Forum banner

Trials and Tribulations of 11Hemi's Custom Exhaust

2024 Views 9 Replies 6 Participants Last post by  klement1
Hello to all,

So I purchased an 11 Laredo X Hemi a few months ago. I wanted to give it a little rumble so I brought it down to the local exhaust shop to have some changes made. Here are my experiences with the different setups we did:

1st setup remove muffler, leave both stock resonators in place:

Quiet at idle with a good gurgle. At partial and full throttle, a very loud and pronounced twang to the exhaust note. Huge loss in torque, MDS not functioning properly. 16 mpg hwy. This was way too loud and I did not like the fuel economy dropping from 21 mpg. 9 out of 10 in terms of volume.

2nd setup replace resonators with Magnaflows:

Recommended to quiet Jeep by shop. Much quieter at idle, gurgle is reduced as well. Partial and full throttle is still loud with a little more torque but nothing compared to stock. MDS still not functioning properly. Mpgs are around 17 hwy. 8 out of 10 in terms of volume.

3rd setup put center muffler back in:

This is the point where I stopped paying for the work and the shop was working to make me happy with the setup. We put the center muffler back in and left the Magnaflows in. Let me say, if you want power, this is the setup to have. With stock being a 4 out of 10 in terms of sound, this setup is a 6. The Jeep goes like a scalded ape. Plenty of tire squealing and just absolute performance all around. Easily knocked a half second off of the 0-60. Feels like sport mode in auto. Sport mode is just nuts. After I got done flogging it, I did a test on the fuel economy. Highway mpg driving like the other two setups netted 14 mpg. MDS still not functioning except on coast and going downhill. Absolutely horrible fuel economy but awesome performance.


I brought the truck back and had the stock resonators put back in. I am back up to 21 mpg on the highway and nice quiet performance. I do not know the science behind the way Jeep set the engine and exhaust up but in my experience, fuel economy is best with the stock setup and the stock setup only. I ate the money I spent on the custom system and called it a life lesson. I did not find on here a good writeup of what happened when you replace the different parts of the system. Had I found one, I may not have done what I did. I figure I would write my first post here to maybe save somebody down the line the aggravation of trying to find out. Happy Jeeping
See less See more
1 - 2 of 10 Posts
I'd like to hear other members thoughts and experiences with the MPG decreasing or if it stayed the same.
I'm surprised they did not mention this, though they do not seem all that scientific if you know what I mean. I think they specialize in making things loud and that is about it. When I came back the first time, their recommendation was to put the mufflers in, not an x-pipe or anything else. I now realize they were just throwing parts at it like a bad mechanic. In the end, I am out $350. Cheap price to pay for the lesson learned.
I'd be mad at $20 lost! Maybe that's just me. But I'd say it's time to look for a new muffler shop.
1 - 2 of 10 Posts
This is an older thread, you may not receive a response, and could be reviving an old thread. Please consider creating a new thread.